Product ID:SUPER CONVOY DARK GRAY, 370 BASE
MSDS Date:04/19/1991
FSC:8040
NIIN:00N021252
Kit Part:Y
MSDS Number: BLTHF

KELLEY TECHNICAL COATINGS

1445 SOUTH 15TH ST
LOUISVILLE, KY 40201-3726
US

Emergency Phone: 502-636-2561; 502-896-1218

Info Phone: 502-636-2561; 502-363-9721

Cage: 8N481

KELLEY TECHNICAL COATINGS

LOUISVILLE, KY 40201-3726 US

Telephone: 502-636-2561;502-363-9721

Cage: 8N481

1.3

CAS: 2807-30-9

RTECS: KM2800000

Fraction By Weight: 3.5%

3.0

CAS: 64742-95-6

Fraction By Weight: 9.1%

ACGIH TLV: 100 PPM (MFR)

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:LIQUID MAY CAUSE EYE BURNS. PROLONGED
SKIN CONTACT WITH LIQUID MAY PRODUCE IRRITATION. EYE, NOSE AND
THROAT IRRITATION MAY RESULT FROM EXPOSURE TO VAPOR. NARCOTIC
EFFECTS OCCUR AT HIGHER CONCENTRATION S OF VAPOR.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:PRE-EXISTING RESPIRATORY, EYE, AND
SKIN CONDITIONS.

First Aid:EYE: IRRIGATE IMMEDIATELY AND THOROUGHLY WITH WATER FOR AT
LEAST 15 MINUTES AND GET MD. SKIN: FLUSH IMMEDIATELY AND THOROUGHLY
WITH WATER. INHAL: REMOVE FROM EXPOSURE, TREAT SYMPTOMATICALLY, AND
GET M D. INGEST: CALL MD IMMEDIATELY .

Flash Point Method:TCC
Flash Point:110F,43C
Lower Limits:1.0%
Extinguishing Media:FOAM, CO2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT . AVOID SOLID STREAM OF WATER, USE FOG FOR
COOLING.
Unusual Fire/Explosion Hazard:FLAMMABLE VAPORS MAY FORM EXPLOSIVE
MIXTURES WITH AIR.

Spill Release Procedures:ELIMINATE ALL IGNITION SOURCES. FLUSH SPILL
AWAY WITH WATER SPRAY. SMALL SPILLS MAY BE COLLECTED WITH ABSORBENT
MATERIAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:MATL IS CLASSIFIED AS FLAM LIQ.KEEP
AWAY FROM HEAT, SPARKS & OPEN FLAME.KEEP CNTNRS CLSD.AVOID EYE
CONT, PRLNGD SKIN CONT & INHAL OF HIGH CONC OF VAP.
Other Precautions:USE W/VENT ADEQ TO MAINTAIN VAP CONC HAZ PROD RESIDUE MAY REMAIN AFTER PROD HAS BEEN REMOVED FROM ITS
CNTNR. DO NOT REUSE "EMPTY" CNTNR W/OUT COMMERCIAL
CLEANING/RECONDITIONING. SEE AL SO 29 CODE OF FEDERAL REG
1910.1000.

Respiratory Protection:A NIOSH/MSHA APPROVED RESPIRATOR FOR ORGANIC
VAPORS SHOULD BE WORN IF NEEDED.
Ventilation:LOCAL EXHAUST RECOMMENDED. MECHANICAL (GENERAL)
RECOMMENDED.
Protective Gloves:PROTECTIVE GLOVES SHOULD BE WORN.
Eye Protection:CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:SAFETY SHOWER AND EYEBATH IN WORK AREA.
Work Hygienic Practices:REMOVE PAINT FROM SKIN CONTACT AFTER EXPOSURE.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.

HCC:F4
Boiling Pt:B.P. Text:300F,149C
Vapor Pres:3.00 @ 68F
Vapor Density:HVR/AIR
Spec Gravity:1.79
Evaporation Rate & Reference:SLOWER THAN BUTYL ACETATE
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:32.60

Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIALS CAN CAUSE A VIGOROUS REACTION.
Stability Condition to Avoid:NOT APPLICABLE.
Hazardous Decomposition Products:AS WITH ANY OTHER ORGANIC MATERIAL,
COMBUSTION WILL PRODUCE CO2 AND PROBABLY CO.

Waste Disposal Methods:MIX WITH A COMPATIBLE CHEMICAL WHICH IS LESS
COMBUSTIBLE AND INCINERATE. OBSERVE ALL FEDERAL, STATE, AND LOCAL
LAWS CONCENRING HEALTH AND POLLUTION.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.